Board logo

Hayabusa help
goaty - 17/2/18 at 09:37 PM

Hi
Got a project, it had already been working but the wiring was a mess.
Since rebuilding the car I have no an issue with what wires do what.
Loom has been adapted already but I am a little lost.

What would be power into the ecu? Orange/white?

Yellow/green, go to earth?

Black/green...no idea on this one.

Starter is wired independent from the engine loom so I can turn it over but need to sort the ecu side of it.

Hoping someone on here has the knowledge.

Cheers guys


bart - 18/2/18 at 12:50 AM

yellow green is not earth defo black is

but !
depends on year of loom
uk or usa
what about the neutral and clutch switch ?
is the alarm plug wiring still there
if it a later loom be careful as there are black live wires as well, and black indicator wires.

some pics might help and more info


ReMan - 18/2/18 at 12:53 AM

any help?
http://www.team-moto.com/HayabusaWireHarness.jpg


goaty - 18/2/18 at 08:22 AM

I have a diagram, which I think is correct one but still a bit lost.

Loom has been stripped back by previous owner so prob got a max of 9 wires left loose.

Neutral is blue and is working.

Yellow/green I though I had read somewhere to earth to act as clutch switch bypass...left loose for the min.

Orange/white I have as ignition live.

Not sure which should feed the switch side of my fuel pump relay.

Black/green I have left loose as no idea on that one.

Orange/yellow (from memory) is earthed via a 100k resistor


goaty - 18/2/18 at 05:04 PM

Just looked and these are the only wires I have that need connecting by the looks for the engine loom.
Orange/Yellow (have 100k resistor to earth)
Yellow/blue (tacho)
Blue (neutral light)
Yellow/green
Orange/white
Black/green
Black/yellow

Tip over switch is in place still.

Hopefully someone can help